Hull & Exterior
- Hull cleaning (pressure wash, anti-fouling removal)
- Anti-fouling paint application
- Hull polishing and waxing
- Gelcoat repair, buffing, and restoration
- Bottom painting
- Anode replacement (sacrificial zincs)
Propulsion & Drivetrain
- Engine service (oil, filters, belts, coolant)
- Inboard/outboard maintenance and rebuilds
- Sterndrive/shaft/propeller inspection, repair, balancing
- Gearbox and transmission service
- Transmission/shaft alignment
- Propeller replacement and repair
Electrical & Electronics
- Battery testing, replacement, and charging systems
- Wiring inspection, corrosion control, and rewiring
- Navigation electronics installation & troubleshooting (GPS, radar, sonar)
- Instrumentation, autopilot, and VHF/communication systems service
- Lighting repairs and upgrades
Plumbing & HVAC
- Bilge pump inspection, replacement, and cleaning
- Freshwater system maintenance (tanks, pumps, filters)
- Sanitation and head system service (macerators, holding tanks)
- Air conditioning/heating service and recharge
- Seacock and thru-hull valve inspection/replacement
Deck & Superstructure
- Deck hardware inspection, lubrication, and replacement
- Winch service and rebuild
- Canvas, upholstery, and bimini repair/cleaning
- Hatch and window seal replacement
- Teak cleaning, sanding, and re-oiling
Inspections & Surveys
- Pre-purchase survey
- Sea trial support and performance testing
Generator Maintenance
Routine Maintenance
- Scheduled oil & filter change
- Fuel filter/water separator replacement
- Air filter inspection/replacement
- Coolant level/check and top-up
- Belt inspection and tensioning
- Battery testing, cleaning, and replacement
- Routine lubrication (accessories, moving parts)
Inspections & Testing
- Visual inspection (leaks, mounts, hoses, wiring)
- Compression and cylinder leak-down tests
- Insulation resistance (megger) testing for windings
- Thermographic inspection for hot spots
- Vibration analysis
- Load bank testing and transient response checks
- Exhaust system inspection (leaks, soot, backpressure)
Fuel System Services
- Fuel polishing and filtration system service
- Injector cleaning, testing, and replacement
- Lift pump and feed pump inspection/repair
- Fuel tank cleaning and sediment removal
- Fuel line inspection and replacement
Cooling System
- Heat exchanger cleaning (raw water & charge air)
- Coolant flush, replacement and corrosion inhibitor treatment
- Raw water pump impeller replacement
- Thermostat and temperature sensor service
Air & Exhaust
- Turbocharger inspection, cleaning, rebuild
- Exhaust manifold and elbow inspection/replacement
- Aftercooler/core cleaning and repair
Electrical & Control Systems
- Starter and alternator service
- Governor calibration and adjustment
- Control panel diagnostics and software updates
- Paralleling system checks and synchronization
- Alarm system testing and sensor calibration
- Remote monitoring installation and configuration
Mechanical Repairs & Overhauls
- Injector and pump overhaul
- Turbocharger rebuilds
- Bearing and crankshaft inspection/replacement
- Cylinder head service and valve adjustment
- Full engine/generator overhaul or replacement
Mounting, Alignment & Vibration
- Foundation and mount inspection
- Shaft and coupling alignment
- Anti-vibration mount replacement and balancing
Exhaust Emissions & Aftertreatment
- Exhaust aftertreatment (SCR, DPF) inspection and service
- Emissions testing and compliance support
Installation & Commissioning
- New genset sizing, selection and installation
- Load integration and transfer switch installation
- Commissioning, sea trials and performance verification